In order to ensure safe production, alert the driver to pay attention to the following points:
First, the combine harvester must first register with the agricultural machinery supervision agency and obtain the number plate and driving permit before putting it into use.
2. Combine harvesters that have not participated in the annual inspection or failed the annual inspection shall not continue to use it.
3. The driver of the combine harvester shall pass the examination of the agricultural machinery supervision agency and obtain the driver's license of the combine harvester before joining the operation.
Fourth, the drive and dangerous parts of the combine harvester should have solid and reliable safety protection devices, and there are obvious safety warning signs.
Fifth, the cab of the combine harvester shall not be overcrowded and shall not place articles that impede safe driving. Personnel related to the operation must be in the prescribed position.
6. Before the combine harvester is started, the gear lever and the power output shaft joystick should be placed in the neutral position; at the time of starting, they should be given a signal or a signal to remind the operator concerned to pay attention to safety.
7. Combine harvester shall not be allowed to drive on the upslope and downslope, make a sharp turn, and turn a vertical slope; the next steep slope shall not be neutral, turn off, or disengage the clutch to slide; when stopping on the slope, reliable anti-skid measures shall be taken.
8. Combine harvesters should maintain, remove debris, and troubleshoot after shutting down or cutting off power. It is forbidden to start the engine or engage the power stop when troubleshooting. It is forbidden to put your hand directly into the food outlet or the grass discharge outlet to eliminate the jam without stopping the machine.
9. Combine harvesters shall be equipped with effective fire-fighting equipment, and lighting equipment for night operation shall be complete and effective.
No fireworks are allowed in the combine harvester operating area. When checking and adding fuel and troubleshooting, do not use open flame lighting.
10. When working with tractors attached to a mounted combine harvester, a Mars collector shall be installed on the exhaust pipe of the engine and the coke shall be cleaned as required.
11. When driving or moving on a road, the combine harvester shall abide by the road traffic safety laws and regulations, obey the command of the traffic police, lock the left and right brake plates, and lift the harvesting platform to its highest position and lock it. Drive at high speed on undulating roads.
12. After the combine harvester is shut down, the work clutch should be cut off, the parking brake device must be locked, and the header should be placed on a reliable support.
13. For combine harvesters operating in cross-region operations, the owner can apply for the “Harvest Harvester Operation Certificate for Combine Harvester†(hereinafter referred to as “Operation Certificateâ€) from the local county-level or above agricultural machinery management department. For those that meet the conditions, the Agricultural Machinery Management Department shall issue the “Operation Certificate†free of charge and register it with the Ministry of Agriculture on a progressive basis.
14. It is forbidden to blindly flow the combine without a clear working site and disrupt the operation of cross-region operations.
15. Combine harvesters, drivers, and auxiliary operators shall strictly follow the requirements of the “Safety Supervision Regulations for Combine Harvesters and Drivers†to prevent agricultural machinery accidents and achieve safe production. If agricultural machinery accidents occur during inter-regional operations, they shall report to the local agricultural machinery management department in time and be subject to investigation and handling.
16. Holding counterfeit "operation permits" or disrupting the operation of cross-region operations, the county-level or above agricultural machinery administrative department shall order them to stop illegal activities, be incorporated into the unified management of the local agricultural machinery management department, and be punished by fines ranging from 50 yuan to 100 yuan; Seriously, it can impose a fine of 100 yuan up to 200 yuan.
17. The agricultural machinery operation site shall be provided with special personnel for management and protection. A security cordon shall be provided around the site.
18. Before the agricultural machinery enters the yard, fire shields shall be installed, and a dry powder fire extinguisher shall be provided for the agricultural product processing workshop or the private plus workshop.
Single Sifter,Flour Single Sifter,Wheat Flour Single Sifter,Maize Flour Single Sifter
HEBEI PINGLE FLOUR MACHINERY GROUP CO., LTD , https://www.plrollermill.com